Hybrid Adaptive Backstepping Sliding Mode Controller of Permanent Magnet Linear Synchronous Motors

Yahiaoui Maamar, Hashim Alnami, I. M. Elzein, Afif Benameur, Brahimi Brahim, Horch Mohamed, Mohamed Metwally Mahmoud

Abstract


This paper tackles the tracking position control dilemma of permanent magnet linear synchronous motors with parameter uncertainties and load force disturbance. Adaptive nonlinear backstepping control augmented with sliding mode control (SMC) is proposed to solve the problem of load force distribution. The backstepping is a recursive control technique where its stability is ensured at each step. However, its sensitivity to uncertainties, disturbances, and electromagnetic noise leads to unwanted performances. SMC is a well-known nonlinear robust approach for uncertain dynamical systems and reduces its parametric adaptive laws.  However, implementing this technique in real-time applications is stopped by its main shortcoming, the undesirable chattering phenomenon.  The saturation function is used to reduce the chattering phenomenon.  The incorporation of these approaches is a promising solution to provide a suitable position tracking of PMLSM in the presence of parameter uncertainties and load force disturbance. The simulation tests have been performed on the PMLSM system to prove the effectiveness and robustness of the proposed controller law.  The results highlighted satisfactory position tracking performance in transient conditions and steady-state and under different load force disturbances.

Keywords


Adaptive Control, Backstepping Sliding Mode Controller, Hybrid Controller, Position Control, Permanent Magnet Linear Synchronous Motors

Full Text:

PDF

References


Z. Li, K. T. Wang, J. S. Wang, Z. H. Zhang, X. Q. Guo, and H. X. Sun, “Cross-coupling control strategy based on intelligent adaptive control for cross-shaped dual-axis linear motors,” IET Electric Power Applications, vol. 17, no. 9, pp. 1212–1224, 2023, https://doi.org/10.1049/elp2.12336.

M. M. Mahmoud, “Improved current control loops in wind side converter with the support of wild horse optimizer for enhancing the dynamic performance of PMSG-based wind generation system,” International Journal of Modelling and Simulation, vol. 43, no. 6, pp. 952-966, 2023, https://doi.org/10.1080/02286203.2022.2139128.

H. Miloudi et al., "Electromagnetic Compatibility Characterization of Start-Capacitor Single-Phase Induction Motor," IEEE Access, vol. 12, pp. 2313-2326, 2024, https://doi.org/10.1109/ACCESS.2023.3349018.

V. Kumar et al., “A Novel Hybrid Harris Hawk Optimization–Sine Cosine Algorithm for Congestion Control in Power Transmission Network,” Energies, vol. 17, no. 19, p. 4985, 2024, https://doi.org/10.3390/en17194985.

D. Fu and X. Zhao, "A Novel Robust Adaptive Nonsingular Fast Integral Terminal Sliding Mode Controller for Permanent Magnet Linear Synchronous Motors," IEEE Journal of Emerging and Selected Topics in Power Electronics, vol. 11, no. 2, pp. 1672-1683, 2023, https://doi.org/10.1109/JESTPE.2022.3229904.

M. M. Mahmoud et al., “Application of Whale Optimization Algorithm Based FOPI Controllers for STATCOM and UPQC to Mitigate Harmonics and Voltage Instability in Modern Distribution Power Grids,” Axioms, vol. 12, no. 5, p. 420, 2023, https://doi.org/10.3390/axioms12050420.

B. S. Atia et al., “Applications of Kepler Algorithm-Based Controller for DC Chopper: Towards Stabilizing Wind Driven PMSGs under Nonstandard Voltages,” Sustainability, vol. 16, no. 7, p. 2952, 2024, https://doi.org/10.3390/su16072952.

B. K. Ponukumati et al., “Evolving fault diagnosis scheme for unbalanced distribution network using fast normalized cross-correlation technique,” PLoS One, vol. 19, no. 10, p. e0305407, 2024, https://doi.org/10.1371/journal.pone.0305407.

F. Wang, K. Chen, S. Zhen, H. Zheng, X. Chen, and F. Chen, “Optimal design of Udwadia–Kalaba theory-based adaptive robust control for permanent magnet linear synchronous motor,” Journal of Vibration and Control, vol. 30, no. 3–4, pp. 616–631, 2024, https://doi.org/10.1177/10775463221149086.

M. Nicola, C. I. Nicola, and D. Selișteanu, “Improvement of PMSM Sensorless Control Based on Synergetic and Sliding Mode Controllers Using a Reinforcement Learning Deep Deterministic Policy Gradient Agent†,” Energies, vol. 15, no. 6, p. 2208, 2022, https://doi.org/10.3390/en15062208.

M. Awad et al., “A review of water electrolysis for green hydrogen generation considering PV/wind/hybrid/hydropower/geothermal/tidal and wave/biogas energy systems, economic analysis, and its application,” Alexandria Engineering Journal, vol. 87, pp. 213–239, 2024, https://doi.org/10.1016/j.aej.2023.12.032.

B. Benbouya, “Dynamic Assessment and Control of a Dual Star Induction Machine State Dedicated to an Electric Vehicle Under Short- Circuit Defect,” International Journal of Robotics and Control Systems, vol. 4, no. 4, pp. 1731–1745, 2024, https://doi.org/10.31763/ijrcs.v4i4.1557.

S. R. K. Joga et al., “Applications of tunable-Q factor wavelet transform and AdaBoost classier for identification of high impedance faults: Towards the reliability of electrical distribution systems,” Energy Exploration & Exploitation, 2024, https://doi.org/10.1177/01445987241260949.

L. Wang, J. Zhao, Z. Yu, Z. Pan and Z. Zheng, "High-Precision Position Control of PMLSM Using Fast Recursive Terminal Sliding Mode With Disturbance Rejection Ability," IEEE Transactions on Industrial Informatics, vol. 20, no. 2, pp. 2577-2588, 2024, https://doi.org/10.1109/TII.2023.3295570.

M. M. Mahmoud, M. K. Ratib, M. M. Aly, and A. M. M. Abdel-Rahim, “Wind-driven permanent magnet synchronous generators connected to a power grid: Existing perspective and future aspects,” Wind Engineering, vol. 46, no. 1, pp. 189–199, 2022, https://doi.org/10.1177/0309524X211022728.

M. M. Mahmoud et al., “Evaluation and Comparison of Different Methods for Improving Fault Ride-Through Capability in Grid-Tied Permanent Magnet Synchronous Wind Generators,” International Transactions on Electrical Energy Systems, vol. 2023, no. 1, pp. 1-22, 2023, https://doi.org/10.1155/2023/7717070.

A. Fatah et al., “Design, and dynamic evaluation of a novel photovoltaic pumping system emulation with DS1104 hardware setup: Towards innovative in green energy systems,” PLoS One, vol. 19, no. 10, p. e0308212, 2024, https://doi.org/10.1371/journal.pone.0308212.

D. Karboua, T. Belgacem, Z. H. Khan, and C. Kellal, “Robust performance comparison of PMSM for flight control applications in more electric aircraft,” PLoS One, vol. 18, no. 7, p. e0283541, 2023, https://doi.org/10.1371/journal.pone.0283541.

N. F. Ibrahim et al., "Operation of Grid-Connected PV System With ANN-Based MPPT and an Optimized LCL Filter Using GRG Algorithm for Enhanced Power Quality," IEEE Access, vol. 11, pp. 106859-106876, 2023, https://doi.org/10.1109/ACCESS.2023.3317980.

O. M. Kamel, A. A. Z. Diab, M. M. Mahmoud, A. S. Al-Sumaiti, and H. M. Sultan, “Performance Enhancement of an Islanded Microgrid with the Support of Electrical Vehicle and STATCOM Systems,” Energies, vol. 16, no. 4, p. 1577, 2023, https://doi.org/10.3390/en16041577.

Y. Kung, “Design and implementation of a high-performance PMLSM drives using DSP chip,” IEEE Transactions on Industrial Electronics, vol. 55, no. 3, pp. 1341–1351, 2008, https://doi.org/10.1109/TIE.2007.909736.

I. E. Maysse et al., "Nonlinear Observer-Based Controller Design for VSC-Based HVDC Transmission Systems Under Uncertainties," IEEE Access, vol. 11, pp. 124014-124030, 2023, https://doi.org/10.1109/ACCESS.2023.3330440.

F. Lin, J. Hwang, P. Chou and Y. Hung, "FPGA-Based Intelligent-Complementary Sliding-Mode Control for PMLSM Servo-Drive System," IEEE Transactions on Power Electronics, vol. 25, no. 10, pp. 2573-2587, 2010, https://doi.org/10.1109/TPEL.2010.2050907.

M. M. Mahmoud et al., “Voltage Quality Enhancement of Low-Voltage Smart Distribution System Using Robust and Optimized DVR Controllers: Application of the Harris Hawks Algorithm,” International Transactions Electrical Energy Systems, vol. 2022, no. 1, pp. 1-18, 2022, https://doi.org/10.1155/2022/4242996.

H. Boudjemai et al., “Application of a Novel Synergetic Control for Optimal Power Extraction of a Small-Scale Wind Generation System with Variable Loads and Wind Speeds,” Symmetry, vol. 15, no. 2, p. 369, 2023, https://doi.org/10.3390/sym15020369.

D. M. Alter and T. C. Tsao, “Control of linear motors for machine tool feed drives: Design and implementation of H∞ optimal feedback control,” Journal of Dynamic Systems, Measurement, and Control, vol. 118, no. 4, pp. 649–656, 1996, https://doi.org/10.1115/1.2802339.

M. M. Mahmoud, B. S. Atia, A. Y. Abdelaziz, and N. A. N. Aldin, “Dynamic Performance Assessment of PMSG and DFIG-Based WECS with the Support of Manta Ray Foraging Optimizer Considering MPPT, Pitch Control, and FRT Capability Issues,” Processes, vol. 10, no. 12, p. 2723, 2022, https://doi.org/10.3390/pr10122723.

N. Benalia et al., “Enhancing electric vehicle charging performance through series-series topology resonance-coupled wireless power transfer,” PLoS One, vol. 19, no. 3, p. e0300550, 2024, https://doi.org/10.1371/journal.pone.0300550.

B. Wang and J. Wang, “Sliding mode control of surface-mount permanent-magnet synchronous motor based on error model with unknown load,” Journal of Software, vol. 6, no. 5, pp. 819–825, 2011, https://www.jsoftware.us/vol6/jsw0605-8.pdf.

M. K. Ratib et al., “Applications of hybrid model predictive control with computational burden reduction for electric drives fed by 3-phase inverter,” Ain Shams Engineering Journal, vol. 14, no. 8, p. 102028, 2023, https://doi.org/10.1016/j.asej.2022.102028.

G. Rigatos, P. Siano, F. Marignetti and I. Gros, "A nonlinear optimal control approach for PM Linear Synchronous Motors," 2018 IEEE 16th International Conference on Industrial Informatics (INDIN), pp. 453-458, 2018, https://doi.org/10.1109/INDIN.2018.8472019.

L. Yu, J. Huang, W. Luo, S. Chang, H. Sun, and H. Tian, “Sliding-Mode Control for PMLSM Position Control—A Review,” Actuators, vol. 12, no. 1, p. 31, 2023, https://doi.org/10.3390/act12010031.

F. F. M. El-Sousy and K. A. Abuhasel, "Adaptive Nonlinear Disturbance Observer Using a Double-Loop Self-Organizing Recurrent Wavelet Neural Network for a Two-Axis Motion Control System," IEEE Transactions on Industry Applications, vol. 54, no. 1, pp. 764-786, 2018, https://doi.org/10.1109/TIA.2017.2763584.

Z. Lei, L. Jian and H. Jia-cai, "Research on predictive functional control based on disturbance observer for PMLSM speed system," 2017 36th Chinese Control Conference (CCC), pp. 4650-4653, 2017, https://doi.org/10.23919/ChiCC.2017.8028088.

T. Chen, D. Cao, J. Yuan, and H. Yang, “Observer-based adaptive neural network backstepping sliding mode control for switched fractional order uncertain nonlinear systems with unmeasured states,” Measurement and Control, vol. 54, no. 7–8, pp. 1245–1258, 2021, https://doi.org/10.1177/00202940211021107.

A. M et al., “Prediction of Optimum Operating Parameters to Enhance the Performance of PEMFC Using Machine Learning Algorithms,” Energy Exploration & Exploitation, 2024, https://doi.org/10.1177/01445987241290535.

Z. Li, S. Zhou, Y. Xiao and L. Wang, "Sensorless Vector Control of Permanent Magnet Synchronous Linear Motor Based on Self-Adaptive Super-Twisting Sliding Mode Controller," IEEE Access, vol. 7, pp. 44998-45011, 2019, https://doi.org/10.1109/ACCESS.2019.2909308.

J. Yang, S. Wang, W. Yu, and L. Yang, “Implementation on adaptive sliding mode position controller of permanent magnet linear synchronous motor,” 2007 International Conference on Electrical Machines and Systems (ICEMS), pp. 468-471, 2007, https://doi.org/10.1109/ICEMS12746.2007.4412008.

F. J. Lin, S. Y. Chen, L. T. Teng, and H. Chu, “Recurrent functional-link-based fuzzy neural network controller with improved particle swarm optimization for a linear synchronous motor drive,” IEEE Transactions on Magnetics, vol. 45, no. 8, pp. 3151-3165, 2009, https://doi.org/10.1109/TMAG.2009.2017530.

Y. Kung, L. T. V. Anh and S. Jou, "FPGA-Realization of Adaptive Fuzzy Controller for the Linear X-Y Table," 2008 Eighth International Conference on Intelligent Systems Design and Applications, pp. 89-94, 2008, https://doi.org/10.1109/ISDA.2008.10.

H. Sun et al., “Research on dual‐mode switching fuzzy PID servo algorithm based on micro‐linear motor,” The Journal of Engineering, vol. 2019, no. 23, pp. 8927–8931, 2019, https://doi.org/10.1049/joe.2018.9150.

X. Zhang and J. Pan, "Nonlinear Robust Sliding Mode Control for PM Linear Synchronous Motors," 2006 CES/IEEE 5th International Power Electronics and Motion Control Conference, pp. 1-5, 2006, https://doi.org/10.1109/IPEMC.2006.4777988.

M. Chebaani, M. M. Mahmoud, A. F. Tazay, M. I. Mosaad, and N. A. Nouraldin, “Extended Kalman Filter design for sensorless sliding mode predictive control of induction motors without weighting factor: An experimental investigation,” PLoS One, vol. 18, no. 11, p. e0293278, 2023, https://doi.org/10.1371/journal.pone.0293278.




DOI: https://doi.org/10.59247/csol.v2i3.165

Refbacks

  • There are currently no refbacks.


Copyright (c) 2024 Yahiaoui Maamar, Mohamed Metwally Mahmoud, Afif Benameur, Brahimi Brahim, Horch Mohamed

 
Control Systems and Optimization Letters
ISSN: 2985-6116
Website: https://ejournal.csol.or.id/index.php/csol
Email: alfian_maarif@ieee.org
Publisher: Peneliti Teknologi Teknik Indonesia
Address: Jl. Empu Sedah No. 12, Pringwulung, Condongcatur, Kec. Depok, Kabupaten Sleman, Daerah Istimewa Yogyakarta 55281, Indonesia